User manual FREEVOX DJ4

[. . . ] FOR ON-ROAD USE ONLY This machine is designed and manufactured for ON-ROAD use only. It is illegal and unsafe to operate this machine on any hills and rough or loose terrain. This machine complies with all applicable ON-ROAD noise level and spark arrester laws and regulation in effect at the time of manufacture. Please check your local riding laws and regulations before operating this machine. A SPECIAL MESSAGES FREEVOX provides many important safety messages both in this manual and on the vehicle. [. . . ] Operator's performance capability is reduced by the influence of alcohol or drugs. WARNING POTENTIAL HAZARD Operating this ATV after consuming alcohol or drugs. HOW TO AVOID THE HAZARD Never consume alcohol or drugs before or while driving this ATV. 96 PRE-OPERATION CHECKS Always perform the pre-operation checks listed on page 58 before riding for safety and proper care of the machine. WARNING POTENTIAL HAZARD Operating this ATV with improper tires, or with improper or uneven tire pressure. WHAT CAN HAPPEN Use of improper tires on this ATV, or operation of this ATV with improper or uneven tire pressure, may cause loss of control, increasing your risk of an accident. HOW TO AVOID THE HAZARD Always use the size and type tires specified in the Owner's Manual for this vehicle on pages 70~72. Always maintain proper tire pressure as described in the Owner's Manual on page71. WARNING POTENTIAL HAZARD Failure to inspect the ATV before operating. WHAT CAN HAPPEN Increases the possibility of an accident or equipment damage. HOW TO AVOID THE HAZARD Always inspect tour ATV each time you use it to make sure the ATV is in safe operating condition. Always follow the inspection and maintenance procedures and schedules described in the Owner's Manual. 97 Do not operate at speeds too fast your skills or the conditions. WARNING POTENTIAL HAZARD Operating this ATV at speeds too fast for your skills or the conditions. WHAT CAN HAPPEN Increases your chances of losing control of the ATV, which can result in an accident. HOW TO AVOID THE HAZARD Always go at a speed that is proper for the terrain, visibility and operating conditions, and your experience. Speed limiter For riders inexperienced with this model, this model is equipped with a speed limiter in the throttle lever housing. Turning the screw in decreases top speed, and turning it out increases top speed. (2) (1) Adjuster (2) Locknut (1) 98 LOADING AND ACCESSORIES Use extra caution when riding the machine with additional loads, such as accessories or cargo. WHAT CAN HAPPEN Increases the chance of an accident, including an overturn. HOW TO AVOID THE HAZARD Never attempt stunts, such as wheelies or jumps. Don't try to show off. 103 EXHAUST SYSTEM The exhaust on the machine is very hot during and following operation. Park the machine in a place where pedestrians or children are not likely to touch it. WARNING POTENTIAL HAZARD Hot exhaust system WHAT CAN HAPPEN Someone touching the exhaust system during or after operation could be burned. Do not park the machine in a place where others might be likely to touch it. 104 PRACTICING Select a flat area to become familiar with your ATV. You should practice control of the throttle, brakes, shifting before trying more difficult terrain. Always avoid riding on rough surfaces: the ATV is designed for on-road use only, and handling maneuvers are more difficult to perform on rough surfaces . Set the parking brake and follow the instruction on page 75~79 to start the engine. Remember that the engine and exhaust pipe will be hot when riding and afterwards; do not allow skin or clothing to come in contact with these components. With the engine idling, return the starter knob to the closed position and shift the drive select lever into the forward position. If the throttle is applied too abruptly, the front wheels may lift off the ground resulting in a loss of directional control. [. . . ] 164 Drive chain slack adjustment. . . . . . . . . . . . 161, 163 DRIVE CHAIN SLACK CHECK. . . . . . . . . . . . . . . . 49, 59, 80 Drive select lever adjustment. . . . . . . . . . . . . . . . . . . . 61 DURING OPERATION. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102 (Cont'd) 195 Page E ENGINE BREAK-IN. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82 ENGINE OIL. . . . . . . . . . . . . . . . . . . . . . . . . 66, 67, 122, 126 EXHAUST SYSTEM. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 104 F FITTINGS AND FASTENERS. . . . . . . . . . . . . . . . . . . . 69 FLAG POLE BRACKET. . . . . . . . . . . . . . . . . . . . . . . . . . . . 55 FRONT BRAKE. . . . . . . . . . . . . . . . . . . . . . . . . 63, 147, 149 FRONT BRAKE LEVER. . . . . . . . . . . . . . . . . . . . 45, 152 FUEL. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64 Fuel gauge. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 33 FUEL TANK CAP. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . [. . . ]